Add slow disk diagnosis to ZED

Slow disk response times can be indicative of a failing drive. ZFS
currently tracks slow I/Os (slower than zio_slow_io_ms) and generates
events (ereport.fs.zfs.delay).  However, no action is taken by ZED,
like is done for checksum or I/O errors.  This change adds slow disk
diagnosis to ZED which is opt-in using new VDEV properties:
  VDEV_PROP_SLOW_IO_N
  VDEV_PROP_SLOW_IO_T

If multiple VDEVs in a pool are undergoing slow I/Os, then it skips
the zpool_vdev_degrade().

Sponsored-By: OpenDrives Inc.
Sponsored-By: Klara Inc.
Reviewed-by: Tony Hutter <hutter2@llnl.gov>
Reviewed-by: Allan Jude <allan@klarasystems.com>
Reviewed-by: Brian Behlendorf <behlendorf1@llnl.gov>
Co-authored-by: Rob Wing <rob.wing@klarasystems.com>
Signed-off-by: Don Brady <don.brady@klarasystems.com>
Closes #15469

cmd/zed/agents/fmd_api.c

@@ -22,6 +22,7 @@
  * Copyright (c) 2004, 2010, Oracle and/or its affiliates. All rights reserved.
  *
  * Copyright (c) 2016, Intel Corporation.
+ * Copyright (c) 2023, Klara Inc.
  */
 
 /*
@@ -231,28 +232,6 @@ fmd_prop_get_int32(fmd_hdl_t *hdl, const char *name)
 	if (strcmp(name, "spare_on_remove") == 0)
 		return (1);
 
-	if (strcmp(name, "io_N") == 0 || strcmp(name, "checksum_N") == 0)
-		return (10);	/* N = 10 events */
-
-	return (0);
-}
-
-int64_t
-fmd_prop_get_int64(fmd_hdl_t *hdl, const char *name)
-{
-	(void) hdl;
-
-	/*
-	 * These can be looked up in mp->modinfo->fmdi_props
-	 * For now we just hard code for phase 2. In the
-	 * future, there can be a ZED based override.
-	 */
-	if (strcmp(name, "remove_timeout") == 0)
-		return (15ULL * 1000ULL * 1000ULL * 1000ULL);	/* 15 sec */
-
-	if (strcmp(name, "io_T") == 0 || strcmp(name, "checksum_T") == 0)
-		return (1000ULL * 1000ULL * 1000ULL * 600ULL);	/* 10 min */
-
 	return (0);
 }
 
@@ -535,6 +514,19 @@ fmd_serd_exists(fmd_hdl_t *hdl, const char *name)
 	return (fmd_serd_eng_lookup(&mp->mod_serds, name) != NULL);
 }
 
+int
+fmd_serd_active(fmd_hdl_t *hdl, const char *name)
+{
+	fmd_module_t *mp = (fmd_module_t *)hdl;
+	fmd_serd_eng_t *sgp;
+
+	if ((sgp = fmd_serd_eng_lookup(&mp->mod_serds, name)) == NULL) {
+		zed_log_msg(LOG_ERR, "serd engine '%s' does not exist", name);
+		return (0);
+	}
+	return (fmd_serd_eng_fired(sgp) || !fmd_serd_eng_empty(sgp));
+}
+
 void
 fmd_serd_reset(fmd_hdl_t *hdl, const char *name)
 {
@@ -543,12 +535,10 @@ fmd_serd_reset(fmd_hdl_t *hdl, const char *name)
 
 	if ((sgp = fmd_serd_eng_lookup(&mp->mod_serds, name)) == NULL) {
 		zed_log_msg(LOG_ERR, "serd engine '%s' does not exist", name);
-		return;
+	} else {
+		fmd_serd_eng_reset(sgp);
+		fmd_hdl_debug(hdl, "serd_reset %s", name);
 	}
-
-	fmd_serd_eng_reset(sgp);
-
-	fmd_hdl_debug(hdl, "serd_reset %s", name);
 }
 
 int
@@ -556,16 +546,21 @@ fmd_serd_record(fmd_hdl_t *hdl, const char *name, fmd_event_t *ep)
 {
 	fmd_module_t *mp = (fmd_module_t *)hdl;
 	fmd_serd_eng_t *sgp;
-	int err;
 
 	if ((sgp = fmd_serd_eng_lookup(&mp->mod_serds, name)) == NULL) {
 		zed_log_msg(LOG_ERR, "failed to add record to SERD engine '%s'",
 		    name);
 		return (0);
 	}
-	err = fmd_serd_eng_record(sgp, ep->ev_hrt);
+	return (fmd_serd_eng_record(sgp, ep->ev_hrt));
+}
 
-	return (err);
+void
+fmd_serd_gc(fmd_hdl_t *hdl)
+{
+	fmd_module_t *mp = (fmd_module_t *)hdl;
+
+	fmd_serd_hash_apply(&mp->mod_serds, fmd_serd_eng_gc, NULL);
 }
 
 /* FMD Timers */
@@ -579,7 +574,7 @@ _timer_notify(union sigval sv)
 	const fmd_hdl_ops_t *ops = mp->mod_info->fmdi_ops;
 	struct itimerspec its;
 
-	fmd_hdl_debug(hdl, "timer fired (%p)", ftp->ft_tid);
+	fmd_hdl_debug(hdl, "%s timer fired (%p)", mp->mod_name, ftp->ft_tid);
 
 	/* disarm the timer */
 	memset(&its, 0, sizeof (struct itimerspec));

cmd/zed/agents/fmd_api.h

@@ -151,7 +151,6 @@ extern void fmd_hdl_vdebug(fmd_hdl_t *, const char *, va_list);
 extern void fmd_hdl_debug(fmd_hdl_t *, const char *, ...);
 
 extern int32_t fmd_prop_get_int32(fmd_hdl_t *, const char *);
-extern int64_t fmd_prop_get_int64(fmd_hdl_t *, const char *);
 
 #define	FMD_STAT_NOALLOC	0x0	/* fmd should use caller's memory */
 #define	FMD_STAT_ALLOC		0x1	/* fmd should allocate stats memory */
@@ -195,10 +194,12 @@ extern size_t fmd_buf_size(fmd_hdl_t *, fmd_case_t *, const char *);
 extern void fmd_serd_create(fmd_hdl_t *, const char *, uint_t, hrtime_t);
 extern void fmd_serd_destroy(fmd_hdl_t *, const char *);
 extern int fmd_serd_exists(fmd_hdl_t *, const char *);
+extern int fmd_serd_active(fmd_hdl_t *, const char *);
 extern void fmd_serd_reset(fmd_hdl_t *, const char *);
 extern int fmd_serd_record(fmd_hdl_t *, const char *, fmd_event_t *);
 extern int fmd_serd_fired(fmd_hdl_t *, const char *);
 extern int fmd_serd_empty(fmd_hdl_t *, const char *);
+extern void fmd_serd_gc(fmd_hdl_t *);
 
 extern id_t fmd_timer_install(fmd_hdl_t *, void *, fmd_event_t *, hrtime_t);
 extern void fmd_timer_remove(fmd_hdl_t *, id_t);

cmd/zed/agents/fmd_serd.c

@@ -310,8 +310,9 @@ fmd_serd_eng_reset(fmd_serd_eng_t *sgp)
 }
 
 void
-fmd_serd_eng_gc(fmd_serd_eng_t *sgp)
+fmd_serd_eng_gc(fmd_serd_eng_t *sgp, void *arg)
 {
+	(void) arg;
 	fmd_serd_elem_t *sep, *nep;
 	hrtime_t hrt;
 

cmd/zed/agents/fmd_serd.h

@@ -77,7 +77,7 @@ extern int fmd_serd_eng_fired(fmd_serd_eng_t *);
 extern int fmd_serd_eng_empty(fmd_serd_eng_t *);
 
 extern void fmd_serd_eng_reset(fmd_serd_eng_t *);
-extern void fmd_serd_eng_gc(fmd_serd_eng_t *);
+extern void fmd_serd_eng_gc(fmd_serd_eng_t *, void *);
 
 #ifdef	__cplusplus
 }

cmd/zed/agents/zfs_diagnosis.c

@@ -23,6 +23,7 @@
  * Copyright (c) 2010, Oracle and/or its affiliates. All rights reserved.
  * Copyright 2015 Nexenta Systems, Inc.  All rights reserved.
  * Copyright (c) 2016, Intel Corporation.
+ * Copyright (c) 2023, Klara Inc.
  */
 
 #include <stddef.h>
@@ -47,11 +48,16 @@
 #define	DEFAULT_CHECKSUM_T	600	/* seconds */
 #define	DEFAULT_IO_N		10	/* events */
 #define	DEFAULT_IO_T		600	/* seconds */
+#define	DEFAULT_SLOW_IO_N	10	/* events */
+#define	DEFAULT_SLOW_IO_T	30	/* seconds */
+
+#define	CASE_GC_TIMEOUT_SECS	43200	/* 12 hours */
 
 /*
- * Our serd engines are named 'zfs_<pool_guid>_<vdev_guid>_{checksum,io}'.  This
+ * Our serd engines are named in the following format:
- * #define reserves enough space for two 64-bit hex values plus the length of
+ *     'zfs_<pool_guid>_<vdev_guid>_{checksum,io,slow_io}'
- * the longest string.
+ * This #define reserves enough space for two 64-bit hex values plus the
+ * length of the longest string.
  */
 #define	MAX_SERDLEN	(16 * 2 + sizeof ("zfs___checksum"))
 
@@ -68,6 +74,7 @@ typedef struct zfs_case_data {
 	int		zc_pool_state;
 	char		zc_serd_checksum[MAX_SERDLEN];
 	char		zc_serd_io[MAX_SERDLEN];
+	char		zc_serd_slow_io[MAX_SERDLEN];
 	int		zc_has_remove_timer;
 } zfs_case_data_t;
 
@@ -114,7 +121,8 @@ zfs_de_stats_t zfs_stats = {
 	{ "resource_drops", FMD_TYPE_UINT64, "resource related ereports" }
 };
 
-static hrtime_t zfs_remove_timeout;
+/* wait 15 seconds after a removal */
+static hrtime_t zfs_remove_timeout = SEC2NSEC(15);
 
 uu_list_pool_t *zfs_case_pool;
 uu_list_t *zfs_cases;
@@ -124,6 +132,8 @@ uu_list_t *zfs_cases;
 #define	ZFS_MAKE_EREPORT(type)	\
     FM_EREPORT_CLASS "." ZFS_ERROR_CLASS "." type
 
+static void zfs_purge_cases(fmd_hdl_t *hdl);
+
 /*
  * Write out the persistent representation of an active case.
  */
@@ -170,6 +180,42 @@ zfs_case_unserialize(fmd_hdl_t *hdl, fmd_case_t *cp)
 	return (zcp);
 }
 
+/*
+ * count other unique slow-io cases in a pool
+ */
+static uint_t
+zfs_other_slow_cases(fmd_hdl_t *hdl, const zfs_case_data_t *zfs_case)
+{
+	zfs_case_t *zcp;
+	uint_t cases = 0;
+	static hrtime_t next_check = 0;
+
+	/*
+	 * Note that plumbing in some external GC would require adding locking,
+	 * since most of this module code is not thread safe and assumes there
+	 * is only one thread running against the module. So we perform GC here
+	 * inline periodically so that future delay induced faults will be
+	 * possible once the issue causing multiple vdev delays is resolved.
+	 */
+	if (gethrestime_sec() > next_check) {
+		/* Periodically purge old SERD entries and stale cases */
+		fmd_serd_gc(hdl);
+		zfs_purge_cases(hdl);
+		next_check = gethrestime_sec() + CASE_GC_TIMEOUT_SECS;
+	}
+
+	for (zcp = uu_list_first(zfs_cases); zcp != NULL;
+	    zcp = uu_list_next(zfs_cases, zcp)) {
+		if (zcp->zc_data.zc_pool_guid == zfs_case->zc_pool_guid &&
+		    zcp->zc_data.zc_vdev_guid != zfs_case->zc_vdev_guid &&
+		    zcp->zc_data.zc_serd_slow_io[0] != '\0' &&
+		    fmd_serd_active(hdl, zcp->zc_data.zc_serd_slow_io)) {
+			cases++;
+		}
+	}
+	return (cases);
+}
+
 /*
  * Iterate over any active cases.  If any cases are associated with a pool or
  * vdev which is no longer present on the system, close the associated case.
@@ -376,6 +422,14 @@ zfs_serd_name(char *buf, uint64_t pool_guid, uint64_t vdev_guid,
 	    (long long unsigned int)vdev_guid, type);
 }
 
+static void
+zfs_case_retire(fmd_hdl_t *hdl, zfs_case_t *zcp)
+{
+	fmd_hdl_debug(hdl, "retiring case");
+
+	fmd_case_close(hdl, zcp->zc_case);
+}
+
 /*
  * Solve a given ZFS case.  This first checks to make sure the diagnosis is
  * still valid, as well as cleaning up any pending timer associated with the
@@ -632,9 +686,7 @@ zfs_fm_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl, const char *class)
 		if (strcmp(class,
 		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_DATA)) == 0 ||
 		    strcmp(class,
-		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_CONFIG_CACHE_WRITE)) == 0 ||
+		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_CONFIG_CACHE_WRITE)) == 0) {
-		    strcmp(class,
-		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_DELAY)) == 0) {
 			zfs_stats.resource_drops.fmds_value.ui64++;
 			return;
 		}
@@ -702,6 +754,9 @@ zfs_fm_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl, const char *class)
 			if (zcp->zc_data.zc_serd_checksum[0] != '\0')
 				fmd_serd_reset(hdl,
 				    zcp->zc_data.zc_serd_checksum);
+			if (zcp->zc_data.zc_serd_slow_io[0] != '\0')
+				fmd_serd_reset(hdl,
+				    zcp->zc_data.zc_serd_slow_io);
 		} else if (fmd_nvl_class_match(hdl, nvl,
 		    ZFS_MAKE_RSRC(FM_RESOURCE_STATECHANGE))) {
 			uint64_t state = 0;
@@ -730,7 +785,11 @@ zfs_fm_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl, const char *class)
 	if (fmd_case_solved(hdl, zcp->zc_case))
 		return;
 
-	fmd_hdl_debug(hdl, "error event '%s'", class);
+	if (vdev_guid)
+		fmd_hdl_debug(hdl, "error event '%s', vdev %llu", class,
+		    vdev_guid);
+	else
+		fmd_hdl_debug(hdl, "error event '%s'", class);
 
 	/*
 	 * Determine if we should solve the case and generate a fault.  We solve
@@ -779,6 +838,8 @@ zfs_fm_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl, const char *class)
 	    fmd_nvl_class_match(hdl, nvl,
 	    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_IO_FAILURE)) ||
 	    fmd_nvl_class_match(hdl, nvl,
+	    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_DELAY)) ||
+	    fmd_nvl_class_match(hdl, nvl,
 	    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_PROBE_FAILURE))) {
 		const char *failmode = NULL;
 		boolean_t checkremove = B_FALSE;
@@ -814,6 +875,51 @@ zfs_fm_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl, const char *class)
 			}
 			if (fmd_serd_record(hdl, zcp->zc_data.zc_serd_io, ep))
 				checkremove = B_TRUE;
+		} else if (fmd_nvl_class_match(hdl, nvl,
+		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_DELAY))) {
+			uint64_t slow_io_n, slow_io_t;
+
+			/*
+			 * Create a slow io SERD engine when the VDEV has the
+			 * 'vdev_slow_io_n' and 'vdev_slow_io_n' properties.
+			 */
+			if (zcp->zc_data.zc_serd_slow_io[0] == '\0' &&
+			    nvlist_lookup_uint64(nvl,
+			    FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_N,
+			    &slow_io_n) == 0 &&
+			    nvlist_lookup_uint64(nvl,
+			    FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_T,
+			    &slow_io_t) == 0) {
+				zfs_serd_name(zcp->zc_data.zc_serd_slow_io,
+				    pool_guid, vdev_guid, "slow_io");
+				fmd_serd_create(hdl,
+				    zcp->zc_data.zc_serd_slow_io,
+				    slow_io_n,
+				    SEC2NSEC(slow_io_t));
+				zfs_case_serialize(zcp);
+			}
+			/* Pass event to SERD engine and see if this triggers */
+			if (zcp->zc_data.zc_serd_slow_io[0] != '\0' &&
+			    fmd_serd_record(hdl, zcp->zc_data.zc_serd_slow_io,
+			    ep)) {
+				/*
+				 * Ignore a slow io diagnosis when other
+				 * VDEVs in the pool show signs of being slow.
+				 */
+				if (zfs_other_slow_cases(hdl, &zcp->zc_data)) {
+					zfs_case_retire(hdl, zcp);
+					fmd_hdl_debug(hdl, "pool %llu has "
+					    "multiple slow io cases -- skip "
+					    "degrading vdev %llu",
+					    (u_longlong_t)
+					    zcp->zc_data.zc_pool_guid,
+					    (u_longlong_t)
+					    zcp->zc_data.zc_vdev_guid);
+				} else {
+					zfs_case_solve(hdl, zcp,
+					    "fault.fs.zfs.vdev.slow_io");
+				}
+			}
 		} else if (fmd_nvl_class_match(hdl, nvl,
 		    ZFS_MAKE_EREPORT(FM_EREPORT_ZFS_CHECKSUM))) {
 			/*
@@ -924,6 +1030,8 @@ zfs_fm_close(fmd_hdl_t *hdl, fmd_case_t *cs)
 		fmd_serd_destroy(hdl, zcp->zc_data.zc_serd_checksum);
 	if (zcp->zc_data.zc_serd_io[0] != '\0')
 		fmd_serd_destroy(hdl, zcp->zc_data.zc_serd_io);
+	if (zcp->zc_data.zc_serd_slow_io[0] != '\0')
+		fmd_serd_destroy(hdl, zcp->zc_data.zc_serd_slow_io);
 	if (zcp->zc_data.zc_has_remove_timer)
 		fmd_timer_remove(hdl, zcp->zc_remove_timer);
 
@@ -932,30 +1040,15 @@ zfs_fm_close(fmd_hdl_t *hdl, fmd_case_t *cs)
 	fmd_hdl_free(hdl, zcp, sizeof (zfs_case_t));
 }
 
-/*
- * We use the fmd gc entry point to look for old cases that no longer apply.
- * This allows us to keep our set of case data small in a long running system.
- */
-static void
-zfs_fm_gc(fmd_hdl_t *hdl)
-{
-	zfs_purge_cases(hdl);
-}
-
 static const fmd_hdl_ops_t fmd_ops = {
 	zfs_fm_recv,	/* fmdo_recv */
 	zfs_fm_timeout,	/* fmdo_timeout */
 	zfs_fm_close,	/* fmdo_close */
 	NULL,		/* fmdo_stats */
-	zfs_fm_gc,	/* fmdo_gc */
+	NULL,	/* fmdo_gc */
 };
 
 static const fmd_prop_t fmd_props[] = {
-	{ "checksum_N", FMD_TYPE_UINT32, "10" },
-	{ "checksum_T", FMD_TYPE_TIME, "10min" },
-	{ "io_N", FMD_TYPE_UINT32, "10" },
-	{ "io_T", FMD_TYPE_TIME, "10min" },
-	{ "remove_timeout", FMD_TYPE_TIME, "15sec" },
 	{ NULL, 0, NULL }
 };
 
@@ -996,8 +1089,6 @@ _zfs_diagnosis_init(fmd_hdl_t *hdl)
 
 	(void) fmd_stat_create(hdl, FMD_STAT_NOALLOC, sizeof (zfs_stats) /
 	    sizeof (fmd_stat_t), (fmd_stat_t *)&zfs_stats);
-
-	zfs_remove_timeout = fmd_prop_get_int64(hdl, "remove_timeout");
 }
 
 void

cmd/zed/agents/zfs_retire.c

@@ -523,6 +523,9 @@ zfs_retire_recv(fmd_hdl_t *hdl, fmd_event_t *ep, nvlist_t *nvl,
 		} else if (fmd_nvl_class_match(hdl, fault,
 		    "fault.fs.zfs.vdev.checksum")) {
 			degrade_device = B_TRUE;
+		} else if (fmd_nvl_class_match(hdl, fault,
+		    "fault.fs.zfs.vdev.slow_io")) {
+			degrade_device = B_TRUE;
 		} else if (fmd_nvl_class_match(hdl, fault,
 		    "fault.fs.zfs.device")) {
 			fault_device = B_FALSE;

cmd/zinject/zinject.c

@@ -1083,6 +1083,22 @@ main(int argc, char **argv)
 			libzfs_fini(g_zfs);
 			return (1);
 		}
+
+		if (record.zi_nlanes) {
+			switch (io_type) {
+			case ZIO_TYPE_READ:
+			case ZIO_TYPE_WRITE:
+			case ZIO_TYPES:
+				break;
+			default:
+				(void) fprintf(stderr, "I/O type for a delay "
+				    "must be 'read' or 'write'\n");
+				usage();
+				libzfs_fini(g_zfs);
+				return (1);
+			}
+		}
+
 		if (!error)
 			error = ENXIO;
 

cmd/zpool/zpool_main.c

@@ -2569,7 +2569,13 @@ print_status_config(zpool_handle_t *zhp, status_cbdata_t *cb, const char *name,
 			break;
 
 		case VDEV_AUX_ERR_EXCEEDED:
-			(void) printf(gettext("too many errors"));
+			if (vs->vs_read_errors + vs->vs_write_errors +
+			    vs->vs_checksum_errors == 0 && children == 0 &&
+			    vs->vs_slow_ios > 0) {
+				(void) printf(gettext("too many slow I/Os"));
+			} else {
+				(void) printf(gettext("too many errors"));
+			}
 			break;
 
 		case VDEV_AUX_IO_FAILURE:

include/sys/fm/fs/zfs.h

@@ -82,6 +82,8 @@ extern "C" {
 #define	FM_EREPORT_PAYLOAD_ZFS_VDEV_CKSUM_T	"vdev_cksum_t"
 #define	FM_EREPORT_PAYLOAD_ZFS_VDEV_IO_N	"vdev_io_n"
 #define	FM_EREPORT_PAYLOAD_ZFS_VDEV_IO_T	"vdev_io_t"
+#define	FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_N	"vdev_slow_io_n"
+#define	FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_T	"vdev_slow_io_t"
 #define	FM_EREPORT_PAYLOAD_ZFS_VDEV_DELAYS	"vdev_delays"
 #define	FM_EREPORT_PAYLOAD_ZFS_PARENT_GUID	"parent_guid"
 #define	FM_EREPORT_PAYLOAD_ZFS_PARENT_TYPE	"parent_type"

include/sys/fs/zfs.h

@@ -364,6 +364,8 @@ typedef enum {
 	VDEV_PROP_IO_N,
 	VDEV_PROP_IO_T,
 	VDEV_PROP_RAIDZ_EXPANDING,
+	VDEV_PROP_SLOW_IO_N,
+	VDEV_PROP_SLOW_IO_T,
 	VDEV_NUM_PROPS
 } vdev_prop_t;
 

include/sys/vdev_impl.h

@@ -22,6 +22,7 @@
  * Copyright (c) 2005, 2010, Oracle and/or its affiliates. All rights reserved.
  * Copyright (c) 2011, 2020 by Delphix. All rights reserved.
  * Copyright (c) 2017, Intel Corporation.
+ * Copyright (c) 2023, Klara Inc.
  */
 
 #ifndef _SYS_VDEV_IMPL_H
@@ -453,12 +454,14 @@ struct vdev {
 	zfs_ratelimit_t vdev_checksum_rl;
 
 	/*
-	 * Checksum and IO thresholds for tuning ZED
+	 * Vdev properties for tuning ZED
 	 */
 	uint64_t	vdev_checksum_n;
 	uint64_t	vdev_checksum_t;
 	uint64_t	vdev_io_n;
 	uint64_t	vdev_io_t;
+	uint64_t	vdev_slow_io_n;
+	uint64_t	vdev_slow_io_t;
 };
 
 #define	VDEV_PAD_SIZE		(8 << 10)

lib/libzfs/libzfs.abi

@@ -5672,7 +5672,9 @@
       <enumerator name='VDEV_PROP_IO_N' value='44'/>
       <enumerator name='VDEV_PROP_IO_T' value='45'/>
       <enumerator name='VDEV_PROP_RAIDZ_EXPANDING' value='46'/>
-      <enumerator name='VDEV_NUM_PROPS' value='47'/>
+      <enumerator name='VDEV_PROP_SLOW_IO_N' value='47'/>
+      <enumerator name='VDEV_PROP_SLOW_IO_T' value='48'/>
+      <enumerator name='VDEV_NUM_PROPS' value='49'/>
     </enum-decl>
     <typedef-decl name='vdev_prop_t' type-id='1573bec8' id='5aa5c90c'/>
     <class-decl name='zpool_load_policy' size-in-bits='256' is-struct='yes' visibility='default' id='2f65b36f'>

lib/libzfs/libzfs_pool.c

@@ -5224,6 +5224,8 @@ zpool_get_vdev_prop_value(nvlist_t *nvprop, vdev_prop_t prop, char *prop_name,
 		case VDEV_PROP_CHECKSUM_T:
 		case VDEV_PROP_IO_N:
 		case VDEV_PROP_IO_T:
+		case VDEV_PROP_SLOW_IO_N:
+		case VDEV_PROP_SLOW_IO_T:
 			if (intval == UINT64_MAX) {
 				(void) strlcpy(buf, "-", len);
 			} else {

lib/libzfs/libzfs_util.c

@@ -1699,7 +1699,9 @@ zprop_parse_value(libzfs_handle_t *hdl, nvpair_t *elem, int prop,
 		    (prop == VDEV_PROP_CHECKSUM_N ||
 		    prop == VDEV_PROP_CHECKSUM_T ||
 		    prop == VDEV_PROP_IO_N ||
-		    prop == VDEV_PROP_IO_T)) {
+		    prop == VDEV_PROP_IO_T ||
+		    prop == VDEV_PROP_SLOW_IO_N ||
+		    prop == VDEV_PROP_SLOW_IO_T)) {
 			*ivalp = UINT64_MAX;
 		}
 

man/man7/vdevprops.7

@@ -44,7 +44,7 @@ section, below.
 Every vdev has a set of properties that export statistics about the vdev
 as well as control various behaviors.
 Properties are not inherited from top-level vdevs, with the exception of
-checksum_n, checksum_t, io_n, and io_t.
+checksum_n, checksum_t, io_n, io_t, slow_io_n, and slow_io_t.
 .Pp
 The values of numeric properties can be specified using human-readable suffixes
 .Po for example,
@@ -117,7 +117,7 @@ If this device is currently being removed from the pool
 .Pp
 The following native properties can be used to change the behavior of a vdev.
 .Bl -tag -width "allocating"
-.It Sy checksum_n , checksum_t , io_n , io_t
+.It Sy checksum_n , checksum_t , io_n , io_t , slow_io_n , slow_io_t
 Tune the fault management daemon by specifying checksum/io thresholds of <N>
 errors in <T> seconds, respectively.
 These properties can be set on leaf and top-level vdevs.

man/man7/zpoolconcepts.7

@@ -260,8 +260,8 @@ sufficient replicas exist to continue functioning.
 The underlying conditions are as follows:
 .Bl -bullet -compact
 .It
-The number of checksum errors exceeds acceptable levels and the device is
+The number of checksum errors or slow I/Os exceeds acceptable levels and the
-degraded as an indication that something may be wrong.
+device is degraded as an indication that something may be wrong.
 ZFS continues to use the device as necessary.
 .It
 The number of I/O errors exceeds acceptable levels.

man/man8/zinject.8

@@ -69,6 +69,7 @@ Force a vdev into the DEGRADED or FAULTED state.
 .Nm zinject
 .Fl d Ar vdev
 .Fl D Ar latency : Ns Ar lanes
+.Op Fl T Ar read|write
 .Ar pool
 .Xc
 Add an artificial delay to I/O requests on a particular

module/zcommon/zpool_prop.c

@@ -431,6 +431,12 @@ vdev_prop_init(void)
 	zprop_register_number(VDEV_PROP_IO_T, "io_t", UINT64_MAX,
 	    PROP_DEFAULT, ZFS_TYPE_VDEV, "<seconds>", "IO_T", B_FALSE,
 	    sfeatures);
+	zprop_register_number(VDEV_PROP_SLOW_IO_N, "slow_io_n", UINT64_MAX,
+	    PROP_DEFAULT, ZFS_TYPE_VDEV, "<events>", "SLOW_IO_N", B_FALSE,
+	    sfeatures);
+	zprop_register_number(VDEV_PROP_SLOW_IO_T, "slow_io_t", UINT64_MAX,
+	    PROP_DEFAULT, ZFS_TYPE_VDEV, "<seconds>", "SLOW_IO_T", B_FALSE,
+	    sfeatures);
 
 	/* default index (boolean) properties */
 	zprop_register_index(VDEV_PROP_REMOVING, "removing", 0,

module/zfs/vdev.c

@@ -676,6 +676,8 @@ vdev_alloc_common(spa_t *spa, uint_t id, uint64_t guid, vdev_ops_t *ops)
 	vd->vdev_checksum_t = vdev_prop_default_numeric(VDEV_PROP_CHECKSUM_T);
 	vd->vdev_io_n = vdev_prop_default_numeric(VDEV_PROP_IO_N);
 	vd->vdev_io_t = vdev_prop_default_numeric(VDEV_PROP_IO_T);
+	vd->vdev_slow_io_n = vdev_prop_default_numeric(VDEV_PROP_SLOW_IO_N);
+	vd->vdev_slow_io_t = vdev_prop_default_numeric(VDEV_PROP_SLOW_IO_T);
 
 	list_link_init(&vd->vdev_config_dirty_node);
 	list_link_init(&vd->vdev_state_dirty_node);
@@ -3730,6 +3732,18 @@ vdev_load(vdev_t *vd)
 		if (error && error != ENOENT)
 			vdev_dbgmsg(vd, "vdev_load: zap_lookup(zap=%llu) "
 			    "failed [error=%d]", (u_longlong_t)zapobj, error);
+
+		error = vdev_prop_get_int(vd, VDEV_PROP_SLOW_IO_N,
+		    &vd->vdev_slow_io_n);
+		if (error && error != ENOENT)
+			vdev_dbgmsg(vd, "vdev_load: zap_lookup(zap=%llu) "
+			    "failed [error=%d]", (u_longlong_t)zapobj, error);
+
+		error = vdev_prop_get_int(vd, VDEV_PROP_SLOW_IO_T,
+		    &vd->vdev_slow_io_t);
+		if (error && error != ENOENT)
+			vdev_dbgmsg(vd, "vdev_load: zap_lookup(zap=%llu) "
+			    "failed [error=%d]", (u_longlong_t)zapobj, error);
 	}
 
 	/*
@@ -5934,6 +5948,20 @@ vdev_prop_set(vdev_t *vd, nvlist_t *innvl, nvlist_t *outnvl)
 			}
 			vd->vdev_io_t = intval;
 			break;
+		case VDEV_PROP_SLOW_IO_N:
+			if (nvpair_value_uint64(elem, &intval) != 0) {
+				error = EINVAL;
+				break;
+			}
+			vd->vdev_slow_io_n = intval;
+			break;
+		case VDEV_PROP_SLOW_IO_T:
+			if (nvpair_value_uint64(elem, &intval) != 0) {
+				error = EINVAL;
+				break;
+			}
+			vd->vdev_slow_io_t = intval;
+			break;
 		default:
 			/* Most processing is done in vdev_props_set_sync */
 			break;
@@ -6269,6 +6297,8 @@ vdev_prop_get(vdev_t *vd, nvlist_t *innvl, nvlist_t *outnvl)
 			case VDEV_PROP_CHECKSUM_T:
 			case VDEV_PROP_IO_N:
 			case VDEV_PROP_IO_T:
+			case VDEV_PROP_SLOW_IO_N:
+			case VDEV_PROP_SLOW_IO_T:
 				err = vdev_prop_get_int(vd, prop, &intval);
 				if (err && err != ENOENT)
 					break;

module/zfs/zfs_fm.c

@@ -222,6 +222,12 @@ vdev_prop_get_inherited(vdev_t *vd, vdev_prop_t prop)
 		case VDEV_PROP_IO_T:
 			propval = vd->vdev_io_t;
 			break;
+		case VDEV_PROP_SLOW_IO_N:
+			propval = vd->vdev_slow_io_n;
+			break;
+		case VDEV_PROP_SLOW_IO_T:
+			propval = vd->vdev_slow_io_t;
+			break;
 		default:
 			propval = propdef;
 			break;
@@ -741,6 +747,26 @@ zfs_ereport_start(nvlist_t **ereport_out, nvlist_t **detector_out,
 			    NULL);
 	}
 
+	if (vd != NULL && strcmp(subclass, FM_EREPORT_ZFS_DELAY) == 0) {
+		uint64_t slow_io_n, slow_io_t;
+
+		slow_io_n = vdev_prop_get_inherited(vd, VDEV_PROP_SLOW_IO_N);
+		if (slow_io_n != vdev_prop_default_numeric(VDEV_PROP_SLOW_IO_N))
+			fm_payload_set(ereport,
+			    FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_N,
+			    DATA_TYPE_UINT64,
+			    slow_io_n,
+			    NULL);
+
+		slow_io_t = vdev_prop_get_inherited(vd, VDEV_PROP_SLOW_IO_T);
+		if (slow_io_t != vdev_prop_default_numeric(VDEV_PROP_SLOW_IO_T))
+			fm_payload_set(ereport,
+			    FM_EREPORT_PAYLOAD_ZFS_VDEV_SLOW_IO_T,
+			    DATA_TYPE_UINT64,
+			    slow_io_t,
+			    NULL);
+	}
+
 	mutex_exit(&spa->spa_errlist_lock);
 
 	*ereport_out = ereport;

module/zfs/zio_inject.c

@@ -605,6 +605,10 @@ zio_handle_io_delay(zio_t *zio)
 		if (vd->vdev_guid != handler->zi_record.zi_guid)
 			continue;
 
+		if (handler->zi_record.zi_iotype != ZIO_TYPES &&
+		    handler->zi_record.zi_iotype != zio->io_type)
+				continue;
+
 		/*
 		 * Defensive; should never happen as the array allocation
 		 * occurs prior to inserting this handler on the list.

tests/runfiles/linux.run

@@ -104,7 +104,8 @@ tags = ['functional', 'devices']
 
 [tests/functional/events:Linux]
 tests = ['events_001_pos', 'events_002_pos', 'zed_rc_filter', 'zed_fd_spill',
-    'zed_cksum_reported', 'zed_cksum_config', 'zed_io_config']
+    'zed_cksum_reported', 'zed_cksum_config', 'zed_io_config',
+    'zed_slow_io', 'zed_slow_io_many_vdevs']
 tags = ['functional', 'events']
 
 [tests/functional/fadvise:Linux]

tests/zfs-tests/tests/Makefile.am

@@ -1447,6 +1447,8 @@ nobase_dist_datadir_zfs_tests_tests_SCRIPTS += \
 	functional/events/zed_fd_spill.ksh \
 	functional/events/zed_io_config.ksh \
 	functional/events/zed_rc_filter.ksh \
+	functional/events/zed_slow_io.ksh \
+	functional/events/zed_slow_io_many_vdevs.ksh \
 	functional/exec/cleanup.ksh \
 	functional/exec/exec_001_pos.ksh \
 	functional/exec/exec_002_neg.ksh \

tests/zfs-tests/tests/functional/cli_root/zpool_get/vdev_get.cfg

@@ -70,4 +70,6 @@ typeset -a properties=(
     checksum_t
     io_n
     io_t
+    slow_io_n
+    slow_io_t
 )

tests/zfs-tests/tests/functional/events/cleanup.ksh

@@ -26,8 +26,10 @@
 
 . $STF_SUITE/include/libtest.shlib
 
-zed_cleanup all-debug.sh all-syslog.sh all-dumpfds
-
 zed_stop
 
+zed_cleanup all-debug.sh all-syslog.sh all-dumpfds
+
+zed_events_drain
+
 default_cleanup

tests/zfs-tests/tests/functional/events/zed_slow_io.ksh

@@ -0,0 +1,205 @@
+#!/bin/ksh -p
+#
+# CDDL HEADER START
+#
+# The contents of this file are subject to the terms of the
+# Common Development and Distribution License (the "License").
+# You may not use this file except in compliance with the License.
+#
+# You can obtain a copy of the license at usr/src/OPENSOLARIS.LICENSE
+# or https://opensource.org/licenses/CDDL-1.0.
+# See the License for the specific language governing permissions
+# and limitations under the License.
+#
+# When distributing Covered Code, include this CDDL HEADER in each
+# file and include the License file at usr/src/OPENSOLARIS.LICENSE.
+# If applicable, add the following below this CDDL HEADER, with the
+# fields enclosed by brackets "[]" replaced with your own identifying
+# information: Portions Copyright [yyyy] [name of copyright owner]
+#
+# CDDL HEADER END
+#
+
+#
+# Copyright (c) 2023, Klara Inc.
+#
+
+# DESCRIPTION:
+#	Verify that vdev properties, slow_io_n and slow_io_t, work with ZED.
+#
+# STRATEGY:
+#	1. Create a pool with single vdev
+#	2. Set slow_io_n/slow_io_t to non-default values
+#	3. Inject slow io errors
+#	4. Verify that ZED degrades vdev
+#
+
+. $STF_SUITE/include/libtest.shlib
+
+TESTDIR="$TEST_BASE_DIR/zed_slow_io"
+VDEV="$TEST_BASE_DIR/vdevfile.$$"
+TESTPOOL="slow_io_pool"
+FILEPATH="$TESTDIR/slow_io.testfile"
+
+OLD_SLOW_IO=$(get_tunable ZIO_SLOW_IO_MS)
+OLD_SLOW_IO_EVENTS=$(get_tunable SLOW_IO_EVENTS_PER_SECOND)
+
+verify_runnable "both"
+
+function do_setup
+{
+	log_must truncate -s 1G $VDEV
+	default_setup_noexit $VDEV
+	zed_events_drain
+	log_must zfs set compression=off $TESTPOOL
+	log_must zfs set primarycache=none $TESTPOOL
+	log_must zfs set prefetch=none $TESTPOOL
+	log_must zfs set recordsize=512 $TESTPOOL
+	for i in {1..10}; do
+		dd if=/dev/urandom of=${FILEPATH}$i bs=512 count=1 2>/dev/null
+	done
+	zpool sync
+}
+
+# intermediate cleanup
+function do_clean
+{
+	log_must zinject -c all
+	log_must zpool destroy $TESTPOOL
+	log_must rm -f $VDEV
+}
+
+# final cleanup
+function cleanup
+{
+	log_must zinject -c all
+
+	# if pool still exists then something failed so log additional info
+	if poolexists $TESTPOOL ; then
+		log_note "$(zpool status -s $TESTPOOL)"
+		echo "=================== zed log search ==================="
+		grep "Diagnosis Engine" $ZEDLET_DIR/zed.log
+		destroy_pool $TESTPOOL
+	fi
+	log_must zed_stop
+
+	log_must rm -f $VDEV
+
+	log_must set_tunable64 ZIO_SLOW_IO_MS $OLD_SLOW_IO
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND $OLD_SLOW_IO_EVENTS
+}
+
+function start_slow_io
+{
+	zpool sync
+	log_must set_tunable64 ZIO_SLOW_IO_MS 10
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND 1000
+
+	log_must zinject -d $VDEV -D10:1 -T read $TESTPOOL
+	zpool sync
+}
+
+function stop_slow_io
+{
+	log_must set_tunable64 ZIO_SLOW_IO_MS $OLD_SLOW_IO
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND $OLD_SLOW_IO_EVENTS
+
+	log_must zinject -c all
+}
+
+# Test default ZED settings:
+#    inject 10 events over 2.5 seconds, should not degrade.
+function default_degrade
+{
+	do_setup
+
+	start_slow_io
+	for i in {1..10}; do
+		dd if=${FILEPATH}$i of=/dev/null count=1 bs=512 2>/dev/null
+		sleep 0.25
+	done
+	stop_slow_io
+	log_note "$(zpool status -s $TESTPOOL)"
+
+	# give slow ZED a chance to process the delay events
+	sleep 18
+	log_note "$(zpool status -s $TESTPOOL)"
+
+	degrades=$(grep "zpool_vdev_degrade" $ZEDLET_DIR/zed.log | wc -l)
+	log_note $degrades vdev degrades in ZED log
+	[ $degrades -eq "0" ] || \
+		log_fail "expecting no degrade events, found $degrades"
+
+	do_clean
+}
+
+# change slow_io_n, slow_io_t to 5 events in 60 seconds
+# fire more than 5 events, should degrade
+function slow_io_degrade
+{
+	do_setup
+
+	zpool set slow_io_n=5 $TESTPOOL $VDEV
+	zpool set slow_io_t=60 $TESTPOOL $VDEV
+
+	start_slow_io
+	for i in {1..16}; do
+		dd if=${FILEPATH}$i of=/dev/null count=1 bs=512 2>/dev/null
+		sleep 0.5
+	done
+	stop_slow_io
+	zpool sync
+
+	#
+	# wait up to 60 seconds for kernel to produce at least 5 delay events
+	#
+	typeset -i i=0
+	typeset -i events=0
+	while [[ $i -lt 60 ]]; do
+		events=$(zpool events | grep "ereport\.fs\.zfs.delay" | wc -l)
+		[[ $events -ge "5" ]] && break
+		i=$((i+1))
+		sleep 1
+	done
+	log_note "$events delay events found"
+
+	if [[ $events -ge "5" ]]; then
+		log_must wait_vdev_state $TESTPOOL $VDEV "DEGRADED" 10
+	fi
+
+	do_clean
+}
+
+# change slow_io_n, slow_io_t to 10 events in 1 second
+# inject events spaced 0.5 seconds apart, should not degrade
+function slow_io_no_degrade
+{
+	do_setup
+
+	zpool set slow_io_n=10 $TESTPOOL $VDEV
+	zpool set slow_io_t=1 $TESTPOOL $VDEV
+
+	start_slow_io
+	for i in {1..16}; do
+		dd if=${FILEPATH}$i of=/dev/null count=1 bs=512 2>/dev/null
+		sleep 0.5
+	done
+	stop_slow_io
+	zpool sync
+
+	log_mustnot wait_vdev_state $TESTPOOL $VDEV "DEGRADED" 45
+
+	do_clean
+}
+
+log_assert "Test ZED slow io configurability"
+log_onexit cleanup
+
+log_must zed_events_drain
+log_must zed_start
+
+default_degrade
+slow_io_degrade
+slow_io_no_degrade
+
+log_pass "Test ZED slow io configurability"

tests/zfs-tests/tests/functional/events/zed_slow_io_many_vdevs.ksh

@@ -0,0 +1,177 @@
+#!/bin/ksh -p
+#
+# CDDL HEADER START
+#
+# The contents of this file are subject to the terms of the
+# Common Development and Distribution License (the "License").
+# You may not use this file except in compliance with the License.
+#
+# You can obtain a copy of the license at usr/src/OPENSOLARIS.LICENSE
+# or https://opensource.org/licenses/CDDL-1.0.
+# See the License for the specific language governing permissions
+# and limitations under the License.
+#
+# When distributing Covered Code, include this CDDL HEADER in each
+# file and include the License file at usr/src/OPENSOLARIS.LICENSE.
+# If applicable, add the following below this CDDL HEADER, with the
+# fields enclosed by brackets "[]" replaced with your own identifying
+# information: Portions Copyright [yyyy] [name of copyright owner]
+#
+# CDDL HEADER END
+#
+
+#
+# Copyright (c) 2023, Klara Inc.
+#
+
+# DESCRIPTION:
+#	Verify that delay events from multiple vdevs doesnt degrade
+#
+# STRATEGY:
+#	1. Create a pool with a 3 disk raidz vdev
+#	2. Inject slow io errors
+#	3. Verify that ZED detects slow I/Os but doesn't degrade any vdevs
+#
+
+. $STF_SUITE/include/libtest.shlib
+
+TESTDIR="$TEST_BASE_DIR/zed_slow_io"
+VDEV1="$TEST_BASE_DIR/vdevfile1.$$"
+VDEV2="$TEST_BASE_DIR/vdevfile2.$$"
+VDEV3="$TEST_BASE_DIR/vdevfile3.$$"
+VDEV4="$TEST_BASE_DIR/vdevfile4.$$"
+VDEVS="$VDEV1 $VDEV2 $VDEV3 $VDEV4"
+TESTPOOL="slow_io_pool"
+FILEPATH="$TESTDIR/slow_io.testfile"
+
+OLD_SLOW_IO=$(get_tunable ZIO_SLOW_IO_MS)
+OLD_SLOW_IO_EVENTS=$(get_tunable SLOW_IO_EVENTS_PER_SECOND)
+
+verify_runnable "both"
+
+function cleanup
+{
+	log_must zinject -c all
+
+	# if pool still exists then something failed so log additional info
+	if poolexists $TESTPOOL ; then
+		log_note "$(zpool status -s $TESTPOOL)"
+		echo "=================== zed log search ==================="
+		grep "Diagnosis Engine" $ZEDLET_DIR/zed.log
+		destroy_pool $TESTPOOL
+	fi
+	log_must zed_stop
+
+	log_must rm -f $VDEVS
+	log_must set_tunable64 ZIO_SLOW_IO_MS $OLD_SLOW_IO
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND $OLD_SLOW_IO_EVENTS
+}
+
+function start_slow_io
+{
+	for vdev in $VDEVS
+	do
+		log_must zpool set slow_io_n=4 $TESTPOOL $vdev
+		log_must zpool set slow_io_t=60 $TESTPOOL $vdev
+	done
+	zpool sync
+
+	log_must set_tunable64 ZIO_SLOW_IO_MS 10
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND 1000
+
+	for vdev in $VDEVS
+	do
+		log_must zinject -d $vdev -D10:1 $TESTPOOL
+	done
+	zpool sync
+}
+
+function stop_slow_io
+{
+	log_must set_tunable64 ZIO_SLOW_IO_MS $OLD_SLOW_IO
+	log_must set_tunable64 SLOW_IO_EVENTS_PER_SECOND $OLD_SLOW_IO_EVENTS
+
+	log_must zinject -c all
+}
+
+function multiple_slow_vdevs_test
+{
+	log_must truncate -s 1G $VDEVS
+	default_raidz_setup_noexit $VDEVS
+
+	log_must zpool events -c
+	log_must zfs set compression=off $TESTPOOL
+	log_must zfs set primarycache=none $TESTPOOL
+	log_must zfs set recordsize=4K $TESTPOOL
+
+	log_must dd if=/dev/urandom of=$FILEPATH bs=1M count=20
+	zpool sync
+
+	#
+	# Read the file with slow io injected on the disks
+	# This will cause multiple errors on each disk to trip ZED SERD
+	#
+	#   pool: slow_io_pool
+	#  state: ONLINE
+	# config:
+	#
+	#         NAME                           STATE  READ WRITE CKSUM  SLOW
+	#         slow_io_pool                   ONLINE    0     0     0     -
+	#           raidz1-0                     ONLINE    0     0     0     -
+	#             /var/tmp/vdevfile1.499278  ONLINE    0     0     0   113
+	#             /var/tmp/vdevfile2.499278  ONLINE    0     0     0   109
+	#             /var/tmp/vdevfile3.499278  ONLINE    0     0     0    96
+	#             /var/tmp/vdevfile4.499278  ONLINE    0     0     0   109
+	#
+	start_slow_io
+	dd if=$FILEPATH of=/dev/null bs=1M count=20 2>/dev/null
+	stop_slow_io
+
+	# count events available for processing
+	typeset -i i=0
+	typeset -i events=0
+	while [[ $i -lt 60 ]]; do
+		events=$(zpool events | grep "ereport\.fs\.zfs.delay" | wc -l)
+		[[ $events -ge "50" ]] && break
+		i=$((i+1))
+		sleep 1
+	done
+	log_note "$events delay events found"
+	if [[ $events -lt "50" ]]; then
+		log_note "bailing: not enough events to complete the test"
+		destroy_pool $TESTPOOL
+		return
+	fi
+
+	#
+	# give slow ZED a chance to process the delay events
+	#
+	typeset -i i=0
+	typeset -i skips=0
+	while [[ $i -lt 75 ]]; do
+		skips=$(grep "retiring case" \
+			$ZEDLET_DIR/zed.log | wc -l)
+		[[ $skips -gt "0" ]] && break
+		i=$((i+1))
+		sleep 1
+	done
+
+	log_note $skips degrade skips in ZED log after $i seconds
+	[ $skips -gt "0" ] || log_fail "expecting to see skips"
+
+	degrades=$(grep "zpool_vdev_degrade" $ZEDLET_DIR/zed.log | wc -l)
+	log_note $degrades vdev degrades in ZED log
+	[ $degrades -eq "0" ] || \
+		log_fail "expecting no degrade events, found $degrades"
+
+	destroy_pool $TESTPOOL
+}
+
+log_assert "Test ZED slow io across multiple vdevs"
+log_onexit cleanup
+
+log_must zed_events_drain
+log_must zed_start
+multiple_slow_vdevs_test
+
+log_pass "Test ZED slow io across multiple vdevs"

tests/zfs-tests/tests/functional/fault/cleanup.ksh

@@ -32,5 +32,6 @@ cleanup_devices $DISKS
 
 zed_stop
 zed_cleanup resilver_finish-start-scrub.sh
+zed_events_drain
 
 log_pass

tests/zfs-tests/tests/functional/fault/setup.ksh

@@ -28,6 +28,7 @@
 
 verify_runnable "global"
 
+zed_events_drain
 zed_setup resilver_finish-start-scrub.sh
 zed_start